Effects of plastic film mulch and tillage on maize productivity and soil parameters

This paper determined the effects of mulching time for double furrows and ridges using plastic film on soil water status, grain yield of maize, soil quality, and economic benefits. The study was conducted in a typical semiarid area during two growing seasons of 2006–2007 with the following three treatments: (i) plastic film mulching at maize sowing with conventional tillage, and the film was removed at harvest (CK); (ii) mulching applied 30 d before sowing with conventional tillage, and the film was removed at harvest (T1); and (iii) mulching at sowing with no-tillage, and the film left on the field after harvest in the first season and used for mulching in the second season (T2). The T1 in both years and T2 in the second year (2007) improved soil water content (in the 0–60 cm layer) and temperature (10 cm) at sowing compared with CK. After the two seasons, the soil water content was significantly higher in the 0–80 cm soil layer in CK and T1, and in the 0–120 cm soil layer in T2; however, it decreased significantly in 140–200 cm soil layer in CK and T1, compared to their initial values at sowing in April 2006, and there was no significant change in T2. The rainfall storage in the 0–200 cm soil layer during the non-growing season (late September 2006 to late April 2007) was 18.2 mm in CK, 34.0 mm in T1, and 59.7 mm in T2, and the rainfall storage in 100–200 cm soil layer was 16.5 and 18.6 mm higher in T2 than in CK and T1, respectively. In 2006, there were no significant differences in yield and water use efficiency (WUE) in all treatments. In 2007, the yield in T1 was significantly higher than in T2, but yields in T2 and CK were not significantly different, and there was no significant difference in WUE among treatments. Soil organic carbon (SOC) (0–20 cm) decreased in CK and T1, but increased (by 2.7%) in T2 at harvesting in September 2007 from the initial value of sowing in April 2006. The ratio of output to input was 1.32:1 for CK, 1.40:1 for T1, and 1.67:1 for T2 averaged across the two seasons. Therefore, T2 was a more sustainable model for increasing water storage, producing greater economic benefit and maintaining SOC balance for maize production in semiarid area.