Post-process treatments are effective strategies to reduce Listeria monocytogenes on the surface of leafy greens: A pilot study

Abstract Growth of L. monocytogenes is among the most important factors affecting the risk of human listeriosis. In ready to eat leafy greens, the use of anti-Listeria treatments represents a good alternative to inhibit growth during storage. Several commercially available antimicrobial agents have been suggested as effective intervention strategies. Among them, phage preparations and bacteriocin-producing strains have shown promising results against L. monocytogenes. In this study, we investigate the efficacy of two commercially available surface treatments, the bacteriophage formulation PhageGuard Listex (Micreos Food Safety B.V., NL) and the bacteriocin-producing culture SafePro® (CHR Hansen, DK) to inactivate L. monocytogenes in fresh-cut curly endive after processing and during storage. Fresh-cut endive was inoculated with a cold-adapted L. monocytogenes cocktail of 6 strains (4.4 ± 0.0 log cfu/g) and treated with the anti-Listeria treatments. The treatments were applied using a spray system at two different places within the processing line, on the conveyor belt and in the centrifuge. A total of 5 different treatments were applied: i) Untreated (CT); ii) PhageGuard Listex on the conveyor belt (Listex_Conveyor); iii) PhageGuard Listex during centrifugation (Listex_Centrifuge); iv) SafePro on the conveyor belt (SafePro_Conveyor); and v) SafePro during centrifugation (SafePro_Centrifuge). Samples were stored 3 days at 5 °C plus 5 days at 8 °C. PhageGuard Listex treatment reduced L. monocytogenes in fresh-cut endive by 2.5 logs, regardless of the place of treatment application (conveyor belt or centrifuge). On the other hand, SafePro only reduced L. monocytogenes by 0.2 and 0.4 logs, at the conveyor belt and centrifuge, respectively. Maximum L. monocytogenes reductions of about 3.5 log units were observed in fresh-cut endive treated with PhageGuard Listex after 3 days of storage. At the end of the shelf life (8 days), the initial trends were maintained and the fresh-cut curly endive treated with PhageGuard Listex showed the lowest L. monocytogenes concentration. However, by the end of the shelf-life, L. monocytogenes showed higher levels (1.3-fold) than immediately after the application of the treatment. One hypothesis could be that L. monocytogenes cells, which were able to survive the anti-Listeria treatments, were also able to proliferate under the specific storage conditions. Based on the obtained results, PhageGuard Listex seems to be a promising decontamination agent for leafy greens aiming to reduce growth of the bacteria but further work is needed.