Effect of sodium alginate on phosphorus recovery by vivianite precipitation

Abstract There are good prospects for phosphorus recovery from excess sludge by vivianite crystallization while a large number of extracellular polymeric substances in sludge will have impact on vivianite precipitation. In this study, as a representative of extracellular polymeric substance, the effect of sodium alginate (SA) on phosphorus recovery by vivianite precipitation under different initial SA concentrations (0–800 mg/L), pH values (6.5–9.0) and Fe/P molar ratios (1:1–2.4:1) was investigated using synthetic wastewater. The results showed that SA in low concentrations (≤400 mg/L) had little inhibitory effect on the phosphorus recovery rate. However, when the concentration of SA was larger than 400 mg/L, the phosphorus recovery rate decreased significantly with increasing SA concentrations. The inhibition rate of 800 mg/L SA was about 3 times as large as that of 400 mg/L SA. It was worth noting that the inhibitory effect of SA on vivianite precipitation decreased with increasing initial pH and Fe/P molar ratios. Additionally, SA has no obvious influence on the composition of products, but the morphology of harvested crystals was transformed from branches to plates or rods in uneven sizes.