The effect of partial replacement of maltodextrin with vegetable fibres in spray-dried white asparagus powder on its physical and aroma properties.

Abstract Asparagus concentrate was spray-dried in different carrier formulations in which maltodextrin was partially replaced by cellulose-based carriers, i.e. asparagus fibre, citrus fibre or microcrystalline cellulose. This replacement was limited to a maximum level of 3 % w/w for asparagus and citrus fibres, and 10 % w/w for microcrystalline cellulose, due to fibre insolubility and increased viscosity of the feed. Powders obtained from feed solutions with an initial solids content of 40 % w/w showed better physical properties and aroma retention than 30 % w/w. Partial replacement of maltodextrin by cellulose-based carriers resulted in powders with similar physical properties as the control and did not detrimentally influence the aroma profiles as analyzed by headspace solid-phase microextraction and gas chromatography–mass spectrometry. This research shows that fibre obtained from asparagus waste streams could potentially be used as a carrier to produce spray-dried asparagus powder with retained key asparagus volatiles such as 2-methoxy-3-isopropyl pyrazine.