The authors report the fabrication of high performance thin film transistors (TFTs) with an amorphous indium gallium zinc oxide (a-IGZO) channel, which was deposited by cosputtering using a dual IGZO and indium zinc oxide (IZO) target. The effect of the indium content on the device performance of the a-IGZO TFTs was investigated. At a relatively low IZO power of 400W, the field-effect mobility (μFE) and subthreshold gate swing (S) of the a-IGZO TFTs were dramatically improved to 19.3cm2∕Vs and 0.35V/decade, respectively, compared to those (11.2cm2∕Vs and 1.11V/decade) for the TFTs with the a-IGZO channel (reference sample) prepared using only the IGZO target. The enhancement in the subthreshold IDS-VGS characteristics at an IZO power of 400W compared to those of the reference sample was attributed to the reduction of the interface trap density rather than the reduction of the bulk defects of the a-IGZO channel.
The effect of the channel deposition pressure on the device performance of amorphous indium-gallium-zinc oxide (a-IGZO) transistors was investigated in detail. The performance of the fabricated transistors improved monotonously with decreasing chamber pressure: at a pressure of 1 mTorr, the field-effect mobility and subthreshold gate swing of the a-IGZO thin-film transistors were dramatically improved to and 0.17 V/decade, respectively, compared to those ( and 0.87 V/decade) of the reference transistors prepared at 5 mTorr. This enhancement in the subthreshold characteristics was attributed to the reduction of the bulk defects of the a-IGZO channel, which might result from the greater densification of the a-IGZO films at the lower deposition pressure.
The composition-dependent structural and electrical properties of p-type SnOx films prepared by reactive DC sputtering at various oxygen partial pressures (PO) and post-heat treatment temperatures (TA) were investigated.
This paper reports the effect of the cation composition on the electrical properties of amorphous indium gallium zinc oxide (a-IGZO) thin-film transistors (TFTs) where atomic layer deposition (ALD) was used to deposit an a-IGZO channel layer. The In0.38Ga0.18Zn0.44O transistors at a 200°C annealing temperature exhibited 39.4 cm2/V·s field effect mobility (µFE), −0.12 V threshold voltage (VTH), 0.40 V/decade subthreshold gate swing (SS), and >107 ION/OFF ratio, corresponding to the state-of-the-art characteristics of transistors with a sputtered IGZO channel. Further enhancement of the μFE value was observed for the devices with a higher In fraction: the In0.45Ga0.15Zn0.40O transistor had a higher μFE value of 48.3 cm2/V·s, −4.06 V VTH, 0.45 V/decade SS, and >107 ION/OFF ratio. The cation composition dependence on the performance of the a-IGZO TFTs was explained by analysing the density-of-state (DOS) distribution for the corresponding devices using the experimental independent variable (IV) and theoretical Technology Computer-aided Design (TCAD) simulation.
'%3e%3cg id='b'%3e%3cpath id='a' stroke='%23000' stroke-width='2' d='M-6-25H6m-12 3H6m-12 3H6'/%3e%3cuse xlink:href='%23a' y='44'/%3e%3c/g%3e%3cpath stroke='%23fff' d='M0 17v10'/%3e%3ccircle r='12' fill='%23cd2e3a'/%3e%3cpath fill='%230047a0' d='M0-12A6 6 0 0 0 0 0a6 6 0 0 1 0 12 12 12 0 0 1 0-24z'/%3e%3c/g%3e%3cg transform='rotate(-123.69)'%3e%3cuse xlink:href='%23b'/%3e%3cpath stroke='%23fff' d='M0-23.5v3M0 17v3.5m0 3v3'/%3e%3c/g%3e%3c/svg%3e)